|
General Corvette Discussions Just general "shootin' the breeze" types of discussions related to Corvettes. |
![Reply](images/buttons/reply.gif) |
|
11-04-2018, 07:46 AM
|
#11
|
Z51
Join Date: Oct 2006
Location: Port Richey FL
Posts: 2,098
Name :
|
Quote:
Originally Posted by Rich Z
Well, if you aren't losing pressure in the fuel line, then that kind of rules out a leak in the fuel system somewhere. A leak would act just like a bad check valve, so you would lose pressure and starting the car would be harder until the fuel pump built fuel pressure back up.
Gasoline evaporates pretty quickly, so you might not necessarily see a wet area from a subtle leak. When I brought the C5Z back home from Aaron Scott's shop, one of the fuel injectors was leaking because of a damaged o-ring seal. That was bad enough that I could see fuel pooling around the injector, but if it set for a while, the fuel would quickly evaporate just leaving the odor behind. But there were other problems that made it difficult to pinpoint where the odor was actually coming from. Gasoline was migrating through the rubber hoses that had been put in the fuel system by Harwood. And the fuel vapor system had been completely disconnected entirely but the plumbing was all still intact.
Yeah, there was a pretty bad gasoline smell in the garage for quite a while, but I was able to get it all straightened out eventually.
BTW, if you have any suspicions about an actual fuel leak, you can put a dye additive in the fuel tank that will show up under UV light and will readily point out any leak you may have there. Even one that has long evaporated, leaving the dye as a residue. The dye stands out like a sore thumb. Actually gasoline itself will show up mildly under UV light too. That is how I saw the gasoline seeping through all the stainless clad rubber hosing in my kluged fuel system. Once I replaced it all with teflon lined hoses, it fixed that problem.
Personally, I would try to find and fix the problem as quickly as possible. Made me REAL nervous to think I was driving a potential torch when I could smell gasoline coming from somewhere.
|
No gas smell at all now. Once the tank gets below half the smells seems to go away. Once i refill i will see if the smell comes back.
|
|
|
11-04-2018, 12:41 PM
|
#12
|
Internet Sanitation Engineer
Join Date: Mar 2006
Location: Crawfordville, FL
Posts: 15,127
Name : Rich Zuchowski
|
Hmm, well my pressure "test" wouldn't apply to an actual leak in the gas tanks somewhere. It only applies to the plumbing above the check valve, since that is what is used to retain fuel pressure when the engine isn't running.
Since all of the plumbing for the gas tanks is at the top of the tanks, I guess there are a number of possible points of failure there that could be the source of a leak.
__________________
|
|
|
11-04-2018, 02:56 PM
|
#13
|
Z51
Join Date: Oct 2006
Location: Port Richey FL
Posts: 2,098
Name :
|
No smell at all now. Once refill i will see if the smell comes back.
|
|
|
11-04-2018, 04:33 PM
|
#14
|
Internet Sanitation Engineer
Join Date: Mar 2006
Location: Crawfordville, FL
Posts: 15,127
Name : Rich Zuchowski
|
Yeah, if you do smell gasoline at fill up, perhaps somewhere in the plumbing at the top of the gas tanks might have a leak somewhere. If that is the case, it would be hell trying to find out where exactly the leak might be at without dropping the gas tanks, however. Which looks like it would be a real pain in the butt job to do.
I replaced the fuel pump in the C5Z but luckily it mounted from the back instead of from the top. But it was still a very tight fit maneuvering the old and new pump even then without dropping the tank any.
Had to replace the fuel pump in Connie's pickup truck a little while back, which also mounts from the top, but in that case I just lifted the bed of the truck off of the frame, and got to it that way.
__________________
|
|
|
11-04-2018, 04:53 PM
|
#15
|
Z51
Join Date: Oct 2006
Location: Port Richey FL
Posts: 2,098
Name :
|
Quote:
Originally Posted by Rich Z
Yeah, if you do smell gasoline at fill up, perhaps somewhere in the plumbing at the top of the gas tanks might have a leak somewhere. If that is the case, it would be hell trying to find out where exactly the leak might be at without dropping the gas tanks, however. Which looks like it would be a real pain in the butt job to do.
I replaced the fuel pump in the C5Z but luckily it mounted from the back instead of from the top. But it was still a very tight fit maneuvering the old and new pump even then without dropping the tank any.
Had to replace the fuel pump in Connie's pickup truck a little while back, which also mounts from the top, but in that case I just lifted the bed of the truck off of the frame, and got to it that way.
|
Not sure if there is a round door that will open with you stick the gas nozzle down into the tank? I don't see it when i look down into the hole. I get the new cap Monday.
|
|
|
11-04-2018, 07:12 PM
|
#16
|
Z51
Join Date: Oct 2006
Location: Port Richey FL
Posts: 2,098
Name :
|
Did some reading and it seems the fender would have to come off and the tank has to be pulled out and a part needs to be replaced. Seems to be a pricey job. Others say also that when the tank is half full the smell goes away and i notice that also. Also some say to remove the Gas cap when you turn off the car and let off on pressure. I sure as heck don't want to go to a dealer and scared they could see i have no Cats and turn me in. So guess i will live with it.
|
|
|
11-05-2018, 12:46 AM
|
#17
|
Internet Sanitation Engineer
Join Date: Mar 2006
Location: Crawfordville, FL
Posts: 15,127
Name : Rich Zuchowski
|
The only time I can think of that there would actually be pressure in the gas tanks is when the car has been sitting for a while, especially in the heat, and the gasoline has begun to evaporate. Normally when driving the car, the fuel pump would try to create a vacuum in the gas tanks as the fuel was being used to run the engine. In the old days, vented gas caps were designed to allow air INTO the gas tank as that vacuum was being created inside.
I don't believe modern cars use vented gas caps any longer. But there has to be some mechanism to compensate for the vacuum being created in the gas tanks while driving. As I mentioned before, there is a canister that is used to recapture fuel vapors from the fuel system that has been known to emit a gasoline odor.
Anyway, hopefully the new gas cap will fix the problem.
__________________
|
|
|
11-05-2018, 06:50 AM
|
#18
|
The Alignment Guy
Join Date: Aug 2007
Location: orlando, fl
Posts: 1,337
Name : Robert J Hinton
|
there was a recall about the gas tanks cracking at where the fuel pump goes into the tank up top.
__________________
the alignment guy
|
|
|
11-05-2018, 07:00 AM
|
#19
|
Z51
Join Date: Oct 2006
Location: Port Richey FL
Posts: 2,098
Name :
|
Quote:
Originally Posted by mrr23
there was a recall about the gas tanks cracking at where the fuel pump goes into the tank up top.
|
I will check with a dealer.
|
|
|
11-06-2018, 07:06 AM
|
#20
|
Z51
Join Date: Oct 2006
Location: Port Richey FL
Posts: 2,098
Name :
|
As long as i keep the gas below half a tank it is fine. I am not paying the money to get it fixed. I would just sell it cheap as is.
|
|
|
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
All times are GMT -4. The time now is 09:40 PM.
|